Abstract:
This paper introduces a new type of switched-mode gate driver, which is capable of operating at high frequencies. This topology satisfies requirements of small passive st...Show MoreMetadata
Abstract:
This paper introduces a new type of switched-mode gate driver, which is capable of operating at high frequencies. This topology satisfies requirements of small passive storage components, low-voltage stress, and high design flexibility. Most popular gate-drive circuits require at least two transistors. The proposed circuit has only a single transistor and is suitable for operation at switching frequencies on the order of several megahertz. The output voltage of the gate driver is a quasi-rectangular waveform shaped by a resonant network to produce the desired gate-source voltage waveform. A detailed steady-state operation of the proposed gate driver is discussed. The power-loss analysis and design procedure are presented. Experimental results are given to verify the presented analytical approach. A laboratory prototype of the gate driver is designed, built, and tested at a switching frequency of 20 MHz.
Published in: IEEE Transactions on Industrial Electronics ( Volume: 67, Issue: 6, June 2020)
References is not available for this document.
Select All
1.
S. Aldhaher, D. Yates, and P. Mitcheson, “Modeling and analysis of class EF and class E/F inverters with series-tuned resonant networks,” IEEE Trans. Power Electron., vol. 31, no. 5, pp. 3415–3430, May 2016.
2.
K. Peng and E. Santi, “Class E resonant inverter optimized design for high frequency (MHz) operation using eGaN HEMTs,” in Proc. IEEE Appl. Power Electron. Conf. Expo., Charlotte, NC, USA, 2015, pp. 2469–2473.
3.
J. Warren, K. Rosowski, and D. Perreault, “Transistor selection and design of a VHF DC–DC power converter,” IEEE Trans. Power Electron., vol. 23, no. 1, pp. 27–37, Jan. 2008.
4.
H. Jedi, A. Ayachit, and M. K. Kazimierczuk, “Resonant gate-drive circuit with reduced switching loss,” in Proc. IEEE Texas Power Energy Conf., College Station, TX, USA, 2018, pp. 1–6.
5.
W. Eberle, Y. Liu, and P. Sen, “A new resonant gate-drive circuit with efficient energy recovery and low conduction loss,” IEEE Trans. Ind. Electron., vol. 55, no. 5, pp. 2213–2221, May 2008.
6.
S. Yin, K. Tseng, C. Tong, and R. Simanjorang, “Design of high-speed gate driver to reduce switching loss and mitigate parasitic effects for SiC MOSFET,” IET Power Electron., vol. 10, no. 10, pp. 1183–1189, Aug. 2017.
7.
M. Theodoridis and S. Mollov, “Robust MOSFET driver for RF, class-D inverters,” IEEE Trans. Ind. Electron., vol. 55, no. 2, pp. 731–740, Feb. 2008.
8.
I. Mashhadi, E. Ovaysi, E. Adib, and H. Farzanehfard, “A novel current-source gate driver for ultra-low-voltage applications,” IEEE Trans. Ind. Electron., vol. 63, no. 8, pp. 4796–4804, Aug. 2016.
9.
D. Maksimovic, “A MOS gate drive with resonant transitions,” in Proc. IEEE Power Electron. Spec. Conf., Cambridge, MA, USA, 1991, pp. 527–532.
10.
W. Zhang, X. Huang, F. Lee, and Q. Li, “Gate drive design considerations for high voltage cascode GaN HEMT,” in Proc. IEEE Appl. Power Electron. Conf. Expo., Fort Worth, TX, USA, 2014, pp. 1484–1489.
11.
I. Vries, J. Nierop, and J. Greene, “Solid state class DE RF power source,” in Proc. IEEE Symp. Ind. Electron., Pretoria, South Africa, 1998, pp. 524–529.
12.
J. Rivas, O. Leitermann, Y. Han, and D. Perreault, “A very high frequency dc–dc converter based on a class \$\Phi _2\$ resonant inverter,” IEEE Trans. Power Electron., vol. 26, no. 10, pp. 2980–2992, Oct. 2011.
13.
H. Jedi, A. Reatti, and M. K. Kazimierczuk, “A current-source sinusoidal gate driver for high-frequency applications,” in Proc. IEEE Int. Symp. Circuits Syst., Florence, Italy, May 27–30, 2018, pp. 1–5.
14.
J. Burkhart, R. Korsunsky, and D. Perreault, “Design methodology for a very high frequency resonant boost converter,” IEEE Trans. Power Electron., vol. 28, no. 4, pp. 1929–1937, Apr. 2013.
15.
R. Podgurski, A. Sagneri, J. Rivas, D. Anderson, and D. Perreault, “Very-high-frequency resonant boost converters,” IEEE Trans. Power Electron., vol. 24, no. 6, pp. 1654–1665, Jun. 2009.
16.
J. Rivas, Y. Han, O. Leitermann, A. Sagneri, and D. Perreault, “A high-frequency resonant inverter topology with low-voltage stress,” IEEE Trans. Power Electron., vol. 23, no. 4, pp. 1759–1771, Jul. 2008.
17.
M. K. Kazimierczuk, Radio-Frequency Power Amplifiers, 2nd. ed. Chichester, U.K. : Wiley, 2015.
18.
Z. Kaczmarczyk, “High-efficiency class E, EF \$_2\$, and E/F \$_3\$ inverters,” IEEE Trans. Ind. Electron., vol. 53, no. 5, pp. 1584–1593, Oct. 2006.
19.
X. Ren, Y. Zhou, D. Wang, X. Zou, and Z. Zhang, “A 10-MHz isolated synchronous class- \$\Phi _2\$ resonant converter,” IEEE Trans. Power Electron., vol. 31, no. 12, pp. 8317–8328, Dec. 2016.
20.
K. Lee, E. Chung, Y. Han, and J. Ha, “A family of high-frequency single-switch DC–DC converters with low switch voltage stress based on impedance networks,” IEEE Trans. Power Electron., vol. 32, no. 4, pp. 2913–2924, Apr. 2017.
21.
A. Juhas and L. Novak, “Comments on class-E, class-C, and class-F power amplifier based upon a finite number of harmonics,” IEEE Trans. Microw. Theory Techn., vol. 57, no. 6, pp. 1623–1625, May 2009.
22.
F. Raab, “Class-E, class-C, and class-F power amplifiers based upon a finite number of harmonics,” IEEE Trans. Microw. Theory Technol., vol. 49, no. 8, pp. 1462–1468, Aug. 2001.
23.
R. Chen and F. Peng, “A high-performance resonant gate-drive circuit for MOSFETs and IGBTs,” IEEE Trans. Power Electron., vol. 29, no. 8, pp. 4366–4373, Aug. 2014.
24.
J. Chennu, R. Maheshwari, and H. Li, “New resonant gate drive circuit for high frequency application of silicon carbide MOSFETs,” IEEE Trans. Ind. Electron., vol. 64, no. 3, pp. 8277–8287, Mar. 2017.
25.
S. Musumeci, “Gate charge control of high-voltage silicon-carbide (SiC) MOSFET in power converter applications,” in Proc. Int. Conf. Clean Elect. Power, 2015, pp. 709–715.
26.
H. Fujita, “A resonant gate-drive circuit capable of high-frequency and high-efficiency operation,” IEEE Trans. Power Electron., vol. 25, no. 4, pp. 962–969 Apr. 2010.
27.
M. K. Kazimierczuk and J. Jozwik, “Resonant dc/dc converter with class-E inverter and class-E rectifier,” IEEE Trans. Ind. Electron, vol. 36, no. 4, pp. 568–578, Nov. 1989.